Differences

This shows you the differences between two versions of the page.

--- blog:escort:work [2024/07/26 18:39] – [Other Technical Info] john
+++ blog:escort:work [2024/08/04 18:09] (current) – [Other Technical Info] john
@@ Line 1: / Line 1: @@
 ====== Escort Work Log ======
-^ Date              ^ Title  ^
+^ Image                                                                                    ^ Date                                        ^ Title                                            ^
-| [[blog:escort:work:lift_pump|2024 / July]]       | Fuel system overhaul - lift pump and swirl tank       |
+|                                                                                          | [[blog:escort:work:fuelling_reset|2024 / August]] | Fuelling Reset - resetting CO/Mixture and idle speed |
+| [[blog:escort:work:lift_pump|{{:blog:escort:work:lift_pump:img20240725151959.jpg?75}}]]  | [[blog:escort:work:lift_pump|2024 / July]]  | Fuel system overhaul - lift pump and swirl tank  |
+==== To-Do List ====
+A reminder of jobs still to do:
+   * Replace ISCV valve, connect wideband O2 sensor and reset base fuelling
+   * Fit AEM AFR sensor pod on side of tunnel for O2 sensor
+   * Refit front struct brace
+   * Remove temporary fuel pressure gauge from engine bay
+   * Remove restrictor from 'R' port on Amal boost valve & re-adjust actuator for 20-25psi
+   * Reseal front and rear windows
+   * Additional vertical bracing for Corsa EPS column
+   * Reshape Corsa column shroud to clear wheel boss
+   * Fabricate a lower column shroud to hide EPS motor etc
+   * Heat up headliner in corners to remove creases
+   * Tracking check
+   * Soften front & rear Gaz shocks
+   * Check brake servo
+   * Rubber isolate the water rail above the exhaust manifold so that it doesn't rub
+   * Fabricate a boot carpet set
+   * Check calibration of fuel level sender and gauge
 ==== Other Technical Info ====
+Mostly single pages of one-off pieces of work, or collected technical information on the work or parts fitted to the [[blog:cars#ford_escort_mk1_cosworth|Escort]].
    * Motorsport Developments information
@@ Line 10: / Line 34: @@
       * [[blog:escort:work:tech:closed_loop|MSD instructions for setting up closed-loop fuelling]]
       * [[blog:escort:work:tech:wasted_spark|MSD instructions for wasted spark driver installation]]
-      * [[blog:escort:work:tech:evochk|MSD instructions for wasted spark driver installation]]
+      * [[blog:escort:work:tech:evochip_and_closed_loop|Combined instructions to use Evolution chip with closed-loop fuelling]]
    * Stack gauges
       * Clubman tachometer
-      * Speedo
+      * Speedometer - including calibration routine
       * Boost
       * Fuel
@@ Line 19: / Line 44: @@
       * Oil pressure
       * Water temp
   * AEM gauges
       * AFR gauge
+  * Corsa Power Steering
+      * [[blog:escort:work:tech:corsa_eps_instructions|Controller instructions]]
+  * [[blog:escort:work:tech:afr_table|AFR to CO table]]