blog:escort:work [Target-Earth]

This page is read only. You can view the source, but not change it. Ask your administrator if you think this is wrong.
====== Escort Work Log ======

^ Image                                                                                    ^ Date                                        ^ Title                                            ^
|                                                                                          | [[blog:escort:work:fuelling_reset|2024 / August]] | Fuelling Reset - resetting CO/Mixture and idle speed |
| [[blog:escort:work:lift_pump|{{:blog:escort:work:lift_pump:img20240725151959.jpg?75}}]]  | [[blog:escort:work:lift_pump|2024 / July]]  | Fuel system overhaul - lift pump and swirl tank  |

==== To-Do List ====

A reminder of jobs still to do:

   * Replace ISCV valve, connect wideband O2 sensor and reset base fuelling
   * Fit AEM AFR sensor pod on side of tunnel for O2 sensor
   * Refit front struct brace
   * Remove temporary fuel pressure gauge from engine bay
   * Remove restrictor from 'R' port on Amal boost valve & re-adjust actuator for 20-25psi
   * Reseal front and rear windows
   * Additional vertical bracing for Corsa EPS column
   * Reshape Corsa column shroud to clear wheel boss
   * Fabricate a lower column shroud to hide EPS motor etc
   * Heat up headliner in corners to remove creases
   * Tracking check
   * Soften front & rear Gaz shocks
   * Check brake servo
   * Rubber isolate the water rail above the exhaust manifold so that it doesn't rub
   * Fabricate a boot carpet set
   * Check calibration of fuel level sender and gauge

==== Other Technical Info ====

Mostly single pages of one-off pieces of work, or collected technical information on the work or parts fitted to the [[blog:cars#ford_escort_mk1_cosworth|Escort]].

   * Motorsport Developments information
      * [[blog:escort:work:evochip|MSD instructions for setting up boost and fuelling for Evolution chip]]
      * [[blog:escort:work:tech:closed_loop|MSD instructions for setting up closed-loop fuelling]]
      * [[blog:escort:work:tech:wasted_spark|MSD instructions for wasted spark driver installation]]
      * [[blog:escort:work:tech:evochip_and_closed_loop|Combined instructions to use Evolution chip with closed-loop fuelling]]

   * Stack gauges
      * Clubman tachometer
      * Speedometer - including calibration routine
      * Boost
      * Fuel
      * Oil temp
      * Oil pressure
      * Water temp

  * AEM gauges
      * AFR gauge

  * Corsa Power Steering
      * [[blog:escort:work:tech:corsa_eps_instructions|Controller instructions]]

  * [[blog:escort:work:tech:afr_table|AFR to CO table]]